Author |
Topic: jeater blower on full permanently (Read 700 times) |
|
Mikesmount
Newbie
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/blank.gif) I'm a YaBB newbie!
Posts: 28
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
jeater blower on full permanently
« on: Jul 21st, 2006, 7:05am » |
Quote Modify
|
My heater.climate control blower was permanently on "full". The advice was to clean the potentiometer first, which I did. This had no effect. Getting the cc panel out was a real pain, because a previous owner had broken the clips and glued the thing in place .... The problem was solved by replacing the Heater Blower Control Module. Obvious really....... But at £159 a pop, not cheap! Fortunately I found a used one. Breakers: Don't throw these little things away! Someone will need one. Anyone got a outside temperature sensor? John
|
|
IP Logged |
|
|
|
johndyork
Junior Member
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/bart.gif) There's a hole in my pocket!
![Email](https://www.fordscorpio.co.uk/YaBBImages/email.gif)
Posts: 73
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #1 on: Aug 6th, 2006, 10:40pm » |
Quote Modify
|
I have similar problem with blower on constantly. When I remove the climate control panel and turn ignition on the blower still blasts away - above message suggests it will be the HBC module - can anyone confirm this? From above message - is the potentiometer the AC switch on the cc panel? Assume this is not at fault if the cc panel removed and blower still blasts away. I have read all the climate control info on the site (2 hrs later...) & will try a reset and fault testing/diagnosis procedures. Any help appreciated. Regards, johndyork.
|
|
IP Logged |
N Reg 2.9 12v Silver Saloon
|
|
|
johndyork
Junior Member
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/bart.gif) There's a hole in my pocket!
![Email](https://www.fordscorpio.co.uk/YaBBImages/email.gif)
Posts: 73
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #2 on: Aug 7th, 2006, 10:12am » |
Quote Modify
|
Spoke to part dealer re blower constantly on and he immediately suggested 'resistor' and said a problem on mondeos. Resistor (FINIS 1017490) £130 + VAT - seems to look like a big relay. Time for some serious fault finding! Any suggestions welcome. Regards, johndyork
|
|
IP Logged |
N Reg 2.9 12v Silver Saloon
|
|
|
Kjetil S
Senior Member
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](http://i44.photobucket.com/albums/f41/kskjon/scorpio/avatars/DSC00007-1.jpg)
2001 BMW 520iat
Posts: 1419
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #3 on: Aug 7th, 2006, 8:33pm » |
Quote Modify
|
Don't pay that for a resistor. It is essentially three pieces of wire (resistance wire) and a thermal fuse.. the fuse can be bought for about £1 and the same with the wires.
|
|
IP Logged |
http://uncyclopedia.org/wiki/Norway
|
|
|
Kjetil S
Senior Member
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](http://i44.photobucket.com/albums/f41/kskjon/scorpio/avatars/DSC00007-1.jpg)
2001 BMW 520iat
Posts: 1419
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #4 on: Aug 7th, 2006, 10:41pm » |
Quote Modify
|
Btw, it should be easy to test. It is located behind a 5x10cm (approx) black cover on top of the blower (just behind the wall behind the engine). Each wire should have a resistance of 1ohm iirc, and the fuse shouldn't have a too high resistance either.
|
|
IP Logged |
http://uncyclopedia.org/wiki/Norway
|
|
|
johndyork
Junior Member
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/bart.gif) There's a hole in my pocket!
![Email](https://www.fordscorpio.co.uk/YaBBImages/email.gif)
Posts: 73
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #5 on: Aug 10th, 2006, 1:41pm » |
Quote Modify
|
Sorted - thanks to John (MikesMount) & Kjetil for ideas. Got a used HBC module from Rotherham Used Ford Spares (£10 + £2pp), arrived next day & works perfectly. Have reset climate control as explained on site and all seems OK. Scorp working pefectly again (for a while)!! Regards, johndyork.
|
|
IP Logged |
N Reg 2.9 12v Silver Saloon
|
|
|
Mikesmount
Newbie
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/blank.gif) I'm a YaBB newbie!
Posts: 28
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #6 on: Aug 14th, 2006, 5:46am » |
Quote Modify
|
Glad you got it sorted! You are from York, I presume? We live "South of the River" - and for once this is not the Thames! Have you got details of the Ford used spares company at Rotherham? Sound like a useful mob! John
|
|
IP Logged |
|
|
|
johndyork
Junior Member
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif) ![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/bart.gif) There's a hole in my pocket!
![Email](https://www.fordscorpio.co.uk/YaBBImages/email.gif)
Posts: 73
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #7 on: Aug 15th, 2006, 10:21pm » |
Quote Modify
|
Hi Mikesmount - normally only go south of the river to get my wallet back & taxis want twice rate after midnight! Rotherham Ford Spares, Unit 4 Lincoln St, Rotherham, South Yorks, S60 1RP tel: 01709364555 or Tel: 07708 775772 email@rotherhamspares.wanadoo.co.uk I have found price and service unbeatable. 'Jack' was person who I spoke to for this and when I bought ABS module and very helpful. Regards, johndyork.
|
|
IP Logged |
N Reg 2.9 12v Silver Saloon
|
|
|
Mikesmount
Newbie
![*](https://www.fordscorpio.co.uk/YaBBImages/star.gif)
![](https://www.fordscorpio.co.uk/YaBBImages/avatars/blank.gif) I'm a YaBB newbie!
Posts: 28
|
![](https://www.fordscorpio.co.uk/YaBBImages/xx.gif) |
Re: jeater blower on full permanently
« Reply #8 on: Aug 17th, 2006, 5:07pm » |
Quote Modify
|
Thanks John! Maybe we can meet up if a local meet is organised?
|
|
IP Logged |
|
|
|
|