Author |
Topic: heaters (Read 1246 times) |
|
spanners
Newbie
I'm a YaBB newbie!
Posts: 24
|
hi chaps, seem to be having the same problems as everyone else regarding the heaters. my parents own a 2.3 ultima estate r reg. they have had it from new and its a belting motor until recently when some un insured driver run into the rear end of ithttp://www.fordscorpio.co.uk/YaBBImages/cry.gif it obviously had nothing to do with the problem but needed to get it off ma chest!!!!! any way no heat is coming out of the heaters using air con or not and also the temp gauge never rises out of the blue. had problem in the past with thermostat, but since replacing it its been ok. i managed to find a scrap scorpio so took the module off it and tried that (resetting the climate control ect....) but still no heat.fault 07. ive also flushed the matrix out at work but im thinking it could be something else. the air con has never been re gassed and as soon as you turn the heaters on the radiator fans come on. i have some knowledge in the motor vehicle industry and im in it for the long haul, but some guidence would be appreciated many thanks gareth!!
|
|
IP Logged |
|
|
|
Highlander
Moderator Expert
13 Scorpios, XR4x4, Suzuki SJ413 for off road :)
Posts: 8244
|
|
Re: heaters
« Reply #1 on: Oct 6th, 2010, 2:45pm » |
Quote Modify
|
Hello and Welcome Are the heater hoses hot going into and out of the bulkhead? Just to clarify, does the heater fan blow but only cold air?
|
|
IP Logged |
on Oct 17th, 2011, 12:35pm, Simmo wrote:I give up ! Too much for an old boy! |
|
|
|
|
spanners
Newbie
I'm a YaBB newbie!
Posts: 24
|
|
Re: heaters
« Reply #2 on: Oct 6th, 2010, 6:55pm » |
Quote Modify
|
yes correct although the top hose is luke warm but would expect at least a small amount of heat the fan does also blow
|
|
IP Logged |
|
|
|
pedropedro
Full Member
Posts: 677
|
|
Re: heaters
« Reply #3 on: Oct 6th, 2010, 7:29pm » |
Quote Modify
|
its the matrix blocked for sure.....ive had this issue for the past 12mths and have a new matrix ready to put in but putting off the day.. mine went cold again a month ago ...spent an hour flushing both ways ..lots of junk came out and now hot again ... for a while if not sorted the inlet hose from the stat to the heater will balloon / split due to high temp worth looking at ..that happened to mine changed the hose easy to check outlet matrix hose temp... at back of water pump
|
|
IP Logged |
|
|
|
scorpio_man
Administrator
Ford Kuga awd
Posts: 5654
|
|
Re: heaters
« Reply #4 on: Oct 6th, 2010, 7:53pm » |
Quote Modify
|
hi there just to confirm, the thermostat has been replaced in the past? if so, how long ago? 2.3's do go through 'stats for some reason, so might need a new one. hth
|
|
IP Logged |
|
|
|
spanners
Newbie
I'm a YaBB newbie!
Posts: 24
|
|
Re: heaters
« Reply #5 on: Oct 7th, 2010, 1:54pm » |
Quote Modify
|
thanks very much for the info, will let you know how i get on will tackle the jobs sometime in the next couple of weeks will replace the stat as they arnt expensive
|
|
IP Logged |
|
|
|
Mike H
Senior Member
Renault Clio
Posts: 2594
|
|
Re: heaters
« Reply #6 on: Oct 7th, 2010, 7:10pm » |
Quote Modify
|
Yes "the temp gauge never gets out of the blue" is a bit of a clue here (?)
|
|
IP Logged |
Mike H
|
|
|
Mike H
Senior Member
Renault Clio
Posts: 2594
|
|
Re: heaters
« Reply #7 on: Oct 7th, 2010, 7:36pm » |
Quote Modify
|
Er, by which I mean if the coolant is only luke warm then so will be the heater (?)
|
|
IP Logged |
Mike H
|
|
|
spanners
Newbie
I'm a YaBB newbie!
Posts: 24
|
|
Re: heaters
« Reply #8 on: Oct 8th, 2010, 4:29pm » |
Quote Modify
|
why will the rad fans come on when the heaters are switched on? is this a knock on effect or another issue?
|
|
IP Logged |
|
|
|
Tompion
Administrator
1997 2.3 Ultima estate.
Posts: 2918
|
|
Re: heaters
« Reply #9 on: Oct 8th, 2010, 11:25pm » |
Quote Modify
|
If the aircon is on with the heating, then the rad fans will run at low speed (when the compressor cycles on).
|
|
IP Logged |
ABS multiplug wheel sensor pins MK IV or MK 20
|
|
|
|