|
||
Title: 98. 2.3 engine pinking Post by scammell_tipper on Aug 4th, 2009, 3:49pm any help please, 63000 miles. regards ivan. |
||
Title: Re: 98. 2.3 engine pinking Post by gozz on Aug 4th, 2009, 4:34pm Best to start by checking all EGR system tubes and pipes etc. GOZZ. |
||
Title: Re: 98. 2.3 engine pinking Post by Highlander on Aug 4th, 2009, 10:22pm I seem to remember a Jonnycab / Pinking thread ;) What was the cause of that Jonny? |
||
Title: Re: 98. 2.3 engine pinking Post by Tekno on Aug 4th, 2009, 11:08pm Can you post a video with sound sample? ;) |
||
Title: Re: 98. 2.3 engine pinking Post by scammell_tipper on Aug 5th, 2009, 12:16pm hi, i am afraid my computer skills are very limited as far as recording sounds not a clue,the pinking sound is very slight when the engine comes under load going up hill otherwise its fine thanks for the replys so far. regards ivan. |
||
Title: Re: 98. 2.3 engine pinking Post by Highlander on Aug 5th, 2009, 12:23pm Hi, Jonnycab's problem turned out to be a camshaft position sensor http://www.fordscorpio.co.uk/cgi-bin/yabb/YaBB.pl?board=Problems;action=display;num=1188073571;start=0#0 |
||
Title: Re: 98. 2.3 engine pinking Post by Tons_of_fun on Aug 5th, 2009, 1:32pm I thought i had pinking under light load which went away under heavy acceleration. Turned out to be a rattling O/S cat ::) ;D |
||
Title: Re: 98. 2.3 engine pinking Post by Jonnycab on Aug 8th, 2009, 1:16am Hi, just got back from holiday & just seen this post :) My pinking was extremely bad.....the kind of pinking you get when the timing is out. Replacing the camshaft position sensor cured the problem immediately :D...... It did come back again slightly & still does occasionally, but nowhere near as bad as before. This slight occasional pinking is now always cured by running some fuel cleaner through the system, & is probably due to slight carbon build up caused by the short journeys & stop/start motoring that my Scorp has to endure being a taxi. Hope this helps :) |
||
Title: Re: 98. 2.3 engine pinking Post by scammell_tipper on Aug 8th, 2009, 10:09am hi,thanks for the help again like you jonnycab i only do short runs is the camshaft position sensor at the rear of the rocker cover on the right with one stud 8mm and a 2 wire plug next to egr valve. i checked egr valve it lifts when you suck through pipe and hoses are all connected [highlands help] regards ivan. |
||
Title: Re: 98. 2.3 engine pinking Post by Jonnycab on Aug 8th, 2009, 10:51am Yep, the camshaft sensor is the one at the rear of the rocker cover next to the egr :) |
||
Title: Re: 98. 2.3 engine pinking Post by scammell_tipper on Aug 8th, 2009, 6:45pm ok,jonnycab thanks i,ll change that, the egr was gozz suggestion sorry. regards. |
||
Title: Re: 98. 2.3 engine pinking Post by scammell_tipper on Aug 9th, 2009, 12:35pm hello, i have changed the camshaft position sensor but the one i put on had a different number on it,orignal no0367 new2446 it now ticksover slightly faster and pinks slightly as i pull away differnt to before,there must be different sensors is it a trip to fords any idea how much anybody regards ivan. |
||
Ford Scorpio Forum » Powered by YaBB 1 Gold - SP 1.3.1! YaBB © 2000-2003. All Rights Reserved. |